Now carefully move the lift up. 41. Take out the engine and transaxle assembly 42. along with support stand. B. ENGINE INSTALLATION 1. Engine installation is generally reverse of removal. Make certain all hardware is tightened to appropriate torque specification. 2. Prior to installing the engine, inspect the condition of the rubber on the engine mounts. Replace the engine mounts if the rubber is damaged. 3. Install the starter motor, AC Compressor, alternator along with its mounting brackets. 4. Mount the transaxle back onto the engine. Tighten the bolts with specified torque. 5. With the vehicle raised on the vehicle lift hoist, place the engine underneath the vehicle, aligned with the engine compartment. 6. Slowly and carefully lower the vehicle body over the engine. 7. Connect the lifting crane to the engine with a chain / belt. Raise the hoist slightly to apply lifting tension to the engine. 8. With the engine attached to the crane, remove the support stand. 9. Secure the engine in the vehicle by attaching the “C”, “A” and “B” mounting brackets. Tighten the mounting bracket hardware at specified torque. Remove the chain / belt after engine mounts 10. are secure. Install the left and right driveshaft assemblies. 11. Connect the gearshift linkage, clutch cable to 12. the engine and transaxle. Connect the engine wiring harness. 13. Connect the cooling system reservoir hoses. 14. Verify the cooling system drain is closed on the radiator. Install the cooling system hoses of the engine, radiator and heater core. To connect the exhaust front pipe tighten the 15. flange near LNT+DPF and connect at rear end. CAUTION Take care when raising the vehicle off the • engine and transaxle assembly. Verify all components and electrical connections are disconnected prior to raising the vehicle, or vehicle damage occurs. CAUTION Use care when lowering the vehicle body , • engine and transaxle assembly. Verify all the engine and other components will not make direct contact or vehicle damage will occur. Diesel Engine Ph-2 (CAFÉ) 107
RkJQdWJsaXNoZXIy MTIwNTUz