SAFARI BSVI SERVICE MANUAL

KRYOTEC ENGINE 119 minutes. Note: Do not shut down engine till the warning lamp goes OFF. If DPF regeneration process requested above is not followed for a long distance and the vehicle is driven with warning lamp ON, it can cause MIL to be turned ON. Once MIL is ON, the please contact TML Service. Service should connect the TML diagnostic tool and conduct DPF service regeneration as indicated in the diagnostic tool. Insufficient DPF regeneration resulting in the above lamps can also happen if the vehicle is driven with adulterated diesel. !! WARNING PARKING WARNING Avoid parking of vehicle over inflammable materials, such as dry leaves; grass etc. as exhaust system is hot enough to initiate fire. ! CAUTION Ensure exhaust system and assembly DOC+DPF is not blocked and is free from obstruction. • Blockages in the exhaust can create back pressure, low top speed, poor pick up, black smoke, carbon build up and low mileage. • Check and ensure EGR Valve & control system is clean and functioning properly. • Excessive carbon build-up / sticky valve. • Damaged vacuum lines. All these can keep the ‘EGR’ open when not desired and vice versa. Either way these can seriously affect power output of the engine and also the emission levels. ! CAUTION The assembly DOC+DPF should not be dropped from a height. If dropped, it should not be used. AdBlue (DIESEL EXHAUST FLUID (DEF)) The vehicle is equipped with an AdBlue Diesel Exhaust Fluid (DEF) injection system and SCR to meet emission standards. These two systems ensure compliance with the diesel emissions requirements; at the same time they ensure fuel- efficiency, handling, torque and power. For messages and system warnings, refer to the “warning lights and messages”. AdBlue (Diesel Exhaust Fluid (DEF)) is a very stable product with a long shelf life. Stored at temperature lower than 90 ° F (32 ° C) has a shelf life of at least one year. The vehicle is equipped with an automatic AdBlue (Diesel Exhaust Fluid (DEF)) heating system when the engine starts allowing the system to work correctly at temperature lower than 12 ° F (-11 ° C). AdBlue (Diesel Exhaust Fluid (DEF)) Storage AdBlue (Diesel Exhaust Fluid (DEF)) is considered a very stable product with a long shelf life. If AdBlue is kept in temperatures between 10 ° and 90 ° F (- 12 ° and 32 ° C), it will last a minimum of one year. AdBlue (Diesel Exhaust Fluid (DEF)) is subject to freezing at the lowest temperature. For example, AdBlue (Diesel Exhaust Fluid (DEF)) may freeze at temperatures at or below 12 ° F (-11 ° C). The system has been designed to operate in this environment. NOTE When working with AdBlue (Diesel Exhaust Fluid (DEF)), it is important to know that  Any containers or parts that come into contact with AdBlue (Diesel Exhaust Fluid (DEF)) must be AdBlue compatible (plastic or stainless steel). Copper, brass, aluminum, iron or non- stainless steel should be avoided as they are susceptible to corrosion by AdBlue (Diesel Exhaust Fluid (DEF)).  If AdBlue (Diesel Exhaust Fluid (DEF)) is spilled, it should be wiped up completely. Adding AdBlue (Diesel Exhaust Fluid (DEF)) Consumption of the additive (Diesel Exhaust Fluid (DEF)) depends on the condition of vehicle use and is indicated by the LED and / or the message on the instrument panel. AdBlue (Diesel Exhaust Fluid (DEF)) freezes freeze at temperatures at or below 12 ° F (-11 ° C). If the car stands for a long time at this temperature refilling could be difficult. For this reason, it is advised to park the vehicle in a garage and / or heated environment and wait for the Diesel Exhaust Fluid (DEF) to return to liquid state before topping up. Proceed as follows: Park the car on flat ground and stop the engine by placing the ignition in the OFF position. Open the fuel door, undo and remove the cap (blue) from the AdBlue (Diesel Exhaust Fluid (DEF)) filler. CAUTION Never fill AdBlue (Diesel Exhaust Fluid (DEF)) or diesel fuel into the wrong filling ports. This may result in serious damage to Engine, fuel system and emission system components. Incase of wrongly filled do not start the engine, contact the authorized dealer.