17 FUELSYSTEM 2.2LDICOR FUELLEVELGAUGE(DASHBOARD): (Fig.22) Removal: check fuel level gauge on dashboard for operation as follows Disconnect the connection on the tank unit under rear carpet. Check fuel gauge on cluster, Fuel gauge shows full with ignition ON. If needle does not show full, check fuse, wiring connector. and fuel level gauge (Dash Board). Replace and retest. FUELLEVELWARNINGLIGHT: (Fig. 23) Drain fuel tank into an approved container refer procedure as mentioned in fuel tank removal. Ensure that the Car is parked on level surface. Add less than 14 liters of fuel and turn the ignition switch ON. The low fuel warning light should come on within 2sec. If light comes ON go to step 5. If light does not come ON or only comes ON dimly check wiring .If OK, remove combination meter and check bulb. If bulb is OK, replace fuel tank gauge. Add fuel so that the total fuel will be more than 14 liters and check that the light goes OFF. if light does not go OFF, check for short circuit in the wiring harness. IF no short circuit, replace fuel tank gauge. If light goesOFF, turn the keyOFF. Test is complete. Fig. 21 Fig. 22 Fig. 23 Fuel level warning light Fuel gauge
RkJQdWJsaXNoZXIy MTIwNTUz