ENGINE 1.3L QUADRAJET (90PS) 86 1. Drain fuel tank into an approved container refer procedure as mentioned in fuel tank removal. 2. Ensure that the car is parked on level surface. 3. Add less than 6 liter of fuel and turn the ignition switch ON. 4. The low fuel warning light should come on within 2 sec. a) If light comes on go to step 5. b) If light does not come ON or only comes ON dimly check wiring. If OK, remove combination meter and check bulb. If bulb is OK, replace fuel level sensor. 5. Add fuel so that the total fuel will be more than 8 lit and check that the light goes OFF. a) If light does not go OFF, check for short circuit in the wiring harness. If no short circuit, replace fuel level sensor. b) If light goes OFF, turn the key OFF. Test is complete. E. FUEL LEVEL WARNING LIGHT : REMOVAL : 1. Check fuel level gauge on dashboard for operation as follows. a) Disconnect the Mating Electrical connector on tank unit under rear seat carpet. b) Check fuel gauge on cluster, Fuel gauge shows zero (empty) with ignition ON. c) By shorting the two wires of sender electrical connector, the fuel gauge will show full. d) If needle does not show full, check fuse, wiring harness, wiring connector and fuel level gauge (Dash board). e) Replace and retest. CAUTION : Q If gauge needle shows full with reconnected wires, check Suction unit Pump gauge unit.
RkJQdWJsaXNoZXIy MTIwNTUz