TIAGO TIGOR BSVI - SERVICE MANUAL - DTC 24-12-2021

TATA BSVI Gasoline Program – EMS ECU Bosch DTC Troubleshooting Service Manual Version: 1.2 Date: 18-12-2019 Prepared By: Sunita Mandlik Checked By: Yeshwant Jadhav Approved By: Satish Kumar Document Part No: 2921 02 xxx xxxx Page: 267 of 1498 Copyright © TATA MOTORS Ltd. This document must not be used in any way, such as copying and redistributing to third parties, without the consent of author. P0171-92: System Too Lean – Performance or Incorrect Operation Overview: ISO Code P0171-92 Customer Symptom Acceleration and Overall vehicle performance will be affected Fault Effects (On Vehicle) 1. Too lean fuel can heat up the engine as well as exhaust components. 2. Acceleration and overall vehicle performance will be affected. 3. Lambda short and long term adaptations will be disabled. Lamp Status (If Any) MIL ON after 3 drive cycles Fault Detection Condition This fault gets logged if the Air content in the Air fuel mixture is higher than required or fuel content is lower than required. Normal Operating Condition Air Fuel Mixture will be appropriate to the Torque and Emissions requirement. Probable Trouble Area Fuel Line, Fuel Regulator, Injectors, Air Intake Circuit, throttle valve Healing Condition Vehicle running and after 3 drive cycles Fault permanent deletion 1. Clear DTC Command form Scan tool 2. Stack Over Flow. 3. 40 warm up cycles. 4. ECU Flashing. 5. ECU Power-Fail Component Details: NA Preliminary Checks: 1. Blocked Fuel Line 2. Bad Fuel Regulator 3. Blocked/Leaking Injectors 4. Intake Air Circuit Leakage. 5. Injector delay time not correct 6. Throttle valve stuck Open 7. Fuel pump relay stuck closed