TIAGO TIGOR BSVI - SERVICE MANUAL - DTC 24-12-2021

TATA BSVI Gasoline Program – EMS ECU Bosch DTC Troubleshooting Service Manual Version: 1.2 Date: 18-12-2019 Prepared By: Sunita Mandlik Checked By: Yeshwant Jadhav Approved By: Satish Kumar Document Part No: 2921 02 xxx xxxx Page: 1028 of 1498 Copyright © TATA MOTORS Ltd. This document must not be used in any way, such as copying and redistributing to third parties, without the consent of author. P3015-04: MCU is blank and free starts are exhausted-System Internal Failures Overview: ISO Code P3015-04 Customer Symptom Vehicle will not start, starter disable Fault Effects (On Vehicle) EMS ecu will cutoff Fuel supply for ignition and disable Starter control signal Lamp Status (If Any) Immo Lamp ON Fault Detection Condition Fault gets logged if the AES key is not written into EMS ecu.Incase this DTC is appearing, pls. note that vehicle is running without the safety function of immobilizer. Normal Operating Condition Immo and EMS are paired in manufacturing while vehicle is dispatched from plant & this DTC is not expected. Incase EMS ecu is replaced & no pairing operation is carried out, this DTC will get logged. Probable Trouble Area EMS ecu Healing Condition After 1 drive cycle of fault rectification Fault Permanent deletion Stack Over flow After 40 drive cycles of fault rectification. Diagnostic command to clear DTC’s Component Details: Immobilizer system is designed to prevent vehicle theft by electronically disabling the engine starting system. The engine can be started only with vehicle’s original immobilizer ignition key, which has an electronic identification programmed code. Immobilizer unit (VICM) is an add-on part on the ignition switch, fitted on the steering column. The engine can be started only with the vehicle’s original immobilizer ignition key. The electronic key communicates the identification code to immobilizer (VICM) when the key is turned to the "Ignition ON" position. Immobilizer comes with two Electronic keys (E-key) Preliminary Checks: 1. Check whether AES key is written into EMS ecu.